Subaru Robin Power Products EHO25A Manuale Utente

RISSUE EMD-EU17172ZZ9020098MODELFOR EMISSION CERTIFIED ENGINEEH025/035取説_米国向EU1717 02.5.15 11:39 AM ページ01

CONTENTS1.SAFETY PRECAUTIONS・・・・・・・・・・・・・・・・・・・・・・・・・・・・12. COMPONENTS ・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・43. PRE-OPERATION CHECKS・・・・・・・・・・・・・・・・・・・

SYMBOLSRead the owner's manual.Stay clear of the hot surface.Exhaust gas is poisonous.Do not operate in an unventilated area.Stop the engine befo

-1-EXHAUST PRECAUTIONSNNever inhale exhaust gasses. They contain carbon monoxide, acolorless, odorless and extremelydangerous gas which can causeuncon

-2-SURROUNDINGSOperate the engine on a stable, levelsurface free of small rocks, loosegravel, etc.PROTECTIVE COVERPlace the protective covers overthe

-3-PRE-OPERATION CHECKS.Carefully check fuel hoses and jointsfor looseness and fuel leakage.Leaked fuel creates a potentiallydangerous situation.Check

2. COMPONENTS-4-Stop switchClutchFuel tankChoke leverCarburetorPrimer pumpStarter handlePlug coverAir cleanerFuel tank capMufflerOil gauge(Oil filler)

-5-EH035Plug coverClutchAir cleanerFuel tank capFuel tankCarburetorChoke leverPrimer pumpStarter handleMufflerOil gauge(Oil filler)Recoil starterEH025

3. PRE-OPERATION CHECKS-6-CHECK ENGINE OILBefore checking or refilling engine oil, besure the engine is located on a stable, levelsurface and stopped.

4. OPERATING YOUR ENGINE-7-ONONOFFPull the starter handle slowly, untilresistance is felt.This is the "compression" point.Return the handle

-8-STOPPINGOFFONOFF1Set the throttle lever at the lowspeed position and allow the engineto run at low speed for 2 or 3minutes before stopping.If the s

NOTICEFEDERAL EMISSION COMPONENT DEFECT WARRANTY and CALIFORNIAEMISSION CONTROL WARRANTY are applicable to only those enginescomplied with EPA (Enviro

5. EASY TROUBLESHOOTING-9-WHEN ENGINE DOES NOTSTART:Perform the following checks beforeyou take the engine to your Robindealer.If you still have troub

-10-WARNINGWipe out spilled fuel carefullybefore checking.Place spark plug as far away fromspark plug hole as possible.Do not hold spark plug by handw

6. MAINTENANCE SCHEDULE-11-DAILY INSPECTIONBefore running the engine, check the following service items.PERIODIC MAINTENANCEPeriodic maintenance is vi

-12-NOTE : Replace rubber hoses for passage every one year. If and when fuel leakage isfound, replace hose at once.Periodic Maintenance Schedule table

7. "HOW-TO" MAINTENANCE-13-INSPECTING THE SPARKPLUGClean off carbon deposits on thespark plug electrode using a plugcleaner or wire brush.Ch

-14-3) Remove the oil gauge, then tilt theengine and drain the oil into a pan orother receptacle.4) Put the engine on a level surface,then fill with t

-15-CLEANING FUEL FILTER Remove the hose clamp and pull outthe fuel filter from fuel pipe. Wash the fuel filter with kerosene.After washing, reassembl

-16-FUEL PIPE REPLACEMENTReplace the fuel pipe every 1 year. If the fuel leakage is found on the fuelpipe, replace it immediately.CHECKING BOLTS, NUTS

8. PREPARATIONS FOR STORAGE-17-ENGINE OILChange the engine oil with fresh oil.Remove the spark plug, pour about 2cc engine oil into the cylinder, slow

9. SPECIFICATIONS-18-MODEL EH025AStarting System Recoil starterTypeAir-Cooled, 4-Stroke, Single Cylinder, Overhead valve,Gasoline EngineFuel Tank Capa

FEDERAL EMISSION COMPONENT DEFECT WARRANTYEMISSION COMPONENT DEFECT WARRANTY COVERAGEThis emission warranty is applicable in all States, except the St

REH025/035取説_米国向EU1717 02.5.15 11:39 AM ページ19

May 2002 CE-YY500PRINTED IN JAPANEH025/035取説_米国向EU1717 02.5.15 11:39 AM ページ21

*Consequential damages such as loss of time, inconvenience, loss of use of the engine of equip-ment, etc.*Diagnosis and inspection charges that do not

CALIFORNIA EMISSION CONTROL WARRANTY STATEMENTYOUR WARRANTY RIGHTS AND OBLIGATIONSThe California Air Resources Board and Fuji Heavy Industries Ltd. ar

LIMITED WARRANTYon Emission Control Systems- California Only -Fuji Heavy Industries Ltd. warrant to the owner of the 2000 and later engine that the en

(2) improper installation, adjustment or repair of the engine or of any warranted partunless performed by an authorized dealer.(3) failure to follow r

(2) Ignition System(i) Spark plug(ii) Flywheel magneto(iii) Ignition coil(3) Miscellaneous Items Used in Above Systems(i) Hoses and sealing gaskets, b

FOREWORDThank you very much for purchasing a ROBIN ENGINE.Your ROBIN ENGINE can supply the power to operate varioussorts of machines and equipment.Ple